California Code Of Regulations, Title 8, Section 1529 Asbestos.

Sealing involves treating the material with a sealant that either binds the asbestos fibers together or coats the material so fibers are not released. Pipe, furnace, and boiler insulation can sometimes be repaired this way. This should be done only by a professional trained to handle asbestos safely. These products are not likely to release asbestos fibers unless sawed, dilled, or cut.

Make sure that the inspection will include a complete visual examination and the careful collection and lab analysis of samples. If asbestos is present, the inspector should provide a written evaluation describing its location and extent of damage, and give recommendations for correction or prevention. Some firms offer combinations of testing, assessment, and correction. A professional hired to assess the need for corrective action should not be connected with an asbestos-correction firm. It is better to use two different firms so there is no conflict of interest. Services vary from one area to another around the country.

Floating Subfloor Over Basement Concrete Ideas

Some gutter companies will offer a large discount if you use them to install new gutters as well. Unless your gutters were installed between 1930–1950, it’s unlikely there’s asbestos in them. Nevertheless, it can be found in asbestos cement roofs and becomes friable when buildings are neglected and the gutters begin to break down. A basic garage with no windows or caulking will usually not have asbestos problems, but windows can, with asbestos namely found in the glaze and caulk around the windows. Add more if there are flooring tiles, drywall, gaskets, or water seals to be removed.

Also, it is as warm as carpet and a great sound absorber. Can the act of separating the tiles from the mastic cause fibers to fly out of the mastic . A copy of the information provided to the physician as required by subsection of this section. The employer shall instruct the physician not to reveal in the written opinion given to the employer specific findings or diagnoses unrelated to occupational exposure to asbestos. Burnishing or dry buffing may be performed only on flooring which has sufficient finish so that the pad cannot contact the flooring material.

Is Asbestos Removal Covered By Insurance?

When I remove asbestos, I double bag it, and put it in the rubbish. Spraying it can release millions of fiber, if it is asbestos. Water with sone soap applied with low pressure, is how a licensed abatement contractor should remove such a thing. They would be wearing tight fitting respirators with P-100 cartridges. Sweep the concrete floor well using a broom and dust pan.

I don’t like chemical strippers for the same reason CX said. I don’t like pouring SLC over anything but a clean surface, either. If the water starts to turn milky white, it means the the product has not been completely washed off. I wet it down and used a rotary chisel to peel everything up. I used a floor scraper to scrape the cutback down to a shadow and tiled over it with a good modified thinset rated to go over cutback. My 9 inch tile had two layers of lino and one layer of stick-down tile on top of it – can we say “encapsulated”?

I have been merrily peeling up the sticky tiles someone put down in the late 70’s until I ran across asbestos info on sticky tiles on the web. The house inspector said absolutely nothing about asbestos tiles when we hired him for $400 to inspect the house. I specifically asked him about where we might black mastic encapsulation expect to find asbestos. He said plumbing insulation perhaps., while standing on the asbestos sticky-tiled floor. I wouldn’t have been able to leave the tile alone once I figured out I could pop them up so easily. I’m glad you posted this because I didn’t know there was asbestos in floor tiles.

Painted Wood Floor

Removing asbestos ceiling tile will cost $3.25 to $6 per square foot depending on how the ceiling tile is installed—whether it’s laid in, stapled, or glued. Most ceiling tile should be removed rather than have another ceiling installed under it, as the old tile can deteriorate. Asbestos tile removal costs around $10 per square foot for nonfriable asbestos. Floor tile usually has to be drilled to be removed because it’s glued or cemented to the floor. Some homeowners opt to install new flooring over it, but this can easily lead to more problems such as redoing the trim and raising the height of the doors. Testing for asbestos after removal costs $200 to $400 to inspect the home again for asbestos levels.

No employer shall engage the services of an asbestos consultant or site surveillance technician unless that person provides proof of certification by the Division. “Asbestos-containing construction material” means any manufactured construction material which contains more than one tenth of 1 percent asbestos by weight. The employer shall maintain all employee training records for one year beyond the last date of employment by that employer.

All scraping of residual adhesive and/or backing shall be performed using wet methods. Vacuums equipped with HEPA filter, disposable dust bag, and metal floor tool shall be used to clean floors. Employee rotation as a means of reducing employee exposure to asbestos. The employer shall ensure that employees do not eat, drink, smoke, chew tobacco or gum, or apply cosmetics in the regulated area. All persons entering a regulated area where employees are required pursuant to subsection of this section to wear respirators shall be supplied with a respirator selected in accordance with subsection of this section. “Presumed Asbestos Containing Material” means thermal system insulation and surfacing material found in buildings constructed no later than 1980.

Press the edge of a small paint scraper against the remaining adhesive and use it to scrape it off of the surface. Rub an 80-grit sanding block over the carpet glue. Sand in the direction of the wood grain so that you avoid scratching the wood.

Panicking over a lamp cord for asbestos is akin to refusing to drink a glass of water because the news reported someone drowning in the ocean. No mention of “new house”, so I presume you’ve been living in the house for a few years already, and until someone told you there MAY BE asbestos you’ve been happy as a clam. If you’ve ever moved, or lowered that lamp much it’s probably already gotcha.

If tiles are removed whole without breakage there is little risk that the asbestos fibres will be released to the air. If you break the vinyl tiles up into tiny pieces when removing them (e.g. use a tile chipper) then it stands to reason that the risk of asbestos fibre release is somewhat greater. There is no legislative requirement for me to do this, I just don’t like breaking up the tiles. There are ways to remove tiles whole using heat pads for example. Yes, the work of removing asbestos from a building has to be done by EPA-licensed asbestos abatement contractors.

As a general matter, any damaged area which is bigger than the size of your hand is not a minor repair. Sometimes, the best way to deal with slightly damaged material is to limit access to the area and not touch or disturb it. Discard damaged or worn asbestos gloves, stove-top pads, or ironing board covers. Check with local health, environmental, or other appropriate officials to find out proper handling and disposal procedures. Hot water and steam pipes in older houses may be coated with an asbestos material or covered with an asbestos blanket or tape. Disturbing it may create a health hazard where none existed before.

Insist that the contractor use the proper equipment to do the job. The workers must wear approved respirators, gloves, and other protective clothing. Asbestos-containing automobile brake pads and linings, clutch facings, and gaskets should be repaired and replaced only by a professional using special protective equipment. Many of these products are now available without asbestos. For more information, read “Guidance for Preventing Asbestos Disease Among Auto Mechanics,” available from regional EPA offices.

SOUNDPROOFING OR DECORATIVE MATERIAL sprayed on walls and ceilings. Loose, crumbly, or water-damaged material may release fibers. So will sanding, drilling, or scraping the material. You also said you want the tiles to stick permanently. Your definition of permanent may be different than mine. Done well you probably will not outlive a good installation.

Only licensed abatement professionals should handle asbestos materials. Now you can get the unmatched beauty and durability of an epoxy floor rather than settling for a retail grade enamel or water based basement floor paint that require constant repainting and cannot be applied to floors with moisture issues. Our Wet Basement Kit allows you to seal in moisture with the highest hydrostatic pressure resistant primer/sealer that is compatible with our epoxy paint. The risk of lung cancer and mesothelioma increases with the number of fibers inhaled.

And as is pointed out above, it’s prolonged exposure that gets you, not short-term. Purchase an adhesive remover specifically made for removing asbestos adhesive. If they are asbestos tiles, there’s not really anything I can do about the tiles at this point.

Keep in mind, new attic insulation costs between $813 and $1492 or $1.50 to $3.00 per square foot. Taped on asbestos can be removed with gloved bags, or the whole wrapped pipe cut out and removed, for $300–$500. It takes one hour at the cost of $250 to glove and remove a 10 ft pipe. Asbestos can be found anywhere inside your home with prices ranging from $10 to $20 per square foot for abatement. Over 60% of your total cost will be attributed to setup and clean-up. Many asbestos professionals will charge a minimum of $1,200 for labor, permits, and disposal.

This spring after working days under my grandmother’s house, my dad got sick. He was initially diagnosed with pneumonia, when it didn’t clear after antibiotics, inoperable lung cancer. The good news is after two months, it cleared up, doctor said it was most likely a fungal infection. If you’ve removed all the residue from the surface I don’t know where any asbestos might come from.

Wish there was was more info out there to warn diy homeowners. Building up the floor wouldn’t really work anyway, because it would create an uneven floor, which would be a real hardship for Matt. As it is, all of the floors through the original part of the house are completely smooth (with the exception of the hallway bathroom, which he won’t use anyway), and I really need to keep them that way so that he can maneuver around easily.

Asbestos Abatement

Building and homeowners should also check to see if the ceilings were ever replaced or renovated. Asbestos was popular in building materials due to its qualities of heat resistance, strength, durability and insulation. Asbestos tiles were widely used because the flooring could hold up to high-traffic areas. Asbestos ceiling tiles also added durability and fireproofing to the buildings. Encapsulation is a method of sealing the surface of materials that contain asbestos to prevent fibers from becoming airborne. Encapsulation is suitable if the material is in good repair and is not soft or crumbly.

• Asbestos removal costs between $20 and $65 per square foot from start to finish including setup, removal, cleanup, and disposal.
• The national average cost to hire an asbestos removal professional is $60 per hour for labor alone.
• I’m not sure how to deal with my stuff and with the legal/formal aspect.
• With the knowledge you’ve gained from this article, I hope you’ll feel comfortable providing quality polished concrete floors where asbestos abatement has occurred.
• You are left with black cut back adhesive that may or may not contain asbestos.
• The product I suggested is to encapsulate the black adhesive.
• This will help prevent even the slightest possibility of the tile chipping or cracking which could lead to serious health issues.
• If you employ soybean glue removers on a wooden floor, then be aware the oil in the soy product may turn the timber a darker colour or shade which may or may not be a concern / issue.
• Make sure that the inspection will include a complete visual examination and the careful collection and lab analysis of samples.
• The employer shall ensure that employees do not smoke in work areas where they are occupationally exposed to asbestos because of activities in that work area.
• In the event of permanent disfigurement, tiles can even be discarded and replaced without disturbing the installation.

Older floors often used mastic that contained asbestos. This can be highly dangerous to workers and inhabitants inside the building. This “black mastic” can slowly affect your employees’ lungs and skin health. In this way, it’s important to test your floor adhesive for asbestos if you are working in an older building. It is safe if it is left alone and encapsulated, such as by covering it with new flooring.

It does not matter if they are solvent, citrus, or soy based, these products are not recommended. Skim coating over a slab where these products have been used will not stop these products. Millions of people ask HomeGuide for cost estimates every year. We track the estimates they get from local companies, then we share those prices with you. Amosite – ranges in size from 0.2 to 0.3 microns and is the least common type of asbestos. The older your home is, the more likely it has extensive amounts of asbestos, especially if it was built before 1970.

Still, it has definite serious health risks and should be avoided where possible. Usually it is safer to seal or encapsulate it rather than remove it. Most cases of serious health issues or death are due to repeated and prolonged exposure to asbestos, usually as a result of occupation. They can be applied over existing or new surfaces, particularly concrete. Epoxy floors are durable and resistant to heat, rust, acid and salt.

The alternative is to remove the glue with a natural product which normally comprise citrus and or soybean basis. I actually don’t know whether or not that’s true. I sure hope you can salvage the original floor! I ended up taking up the old flooring in my kitchen and putting down new oak hardwood floor, but that’s not because of asbestos. It was because the original floor was in such bad shape that it was really not salvageable.

Any leftover epoxy should be put into small jars for safe keeping in case of a any emergency touch up repairs needed. Each kit will cover up to 600 Sf depending on porosity of the slab and texture of the slab. Please note that lighter colors such as Beige will yield less coverage also. We recommend at least a 10-15% safety factor when calculating the square footage of your floor. Our basement epoxy is a three part epoxy versus the typical two part epoxy which contains a built in primer with our patent pending adaptive molecular technology which allows it to bond to less than perfect surfaces.

Source: homemakerguide.com